Pages: 1 2 [3]   Go Down

Author Topic: Car died while driving  (Read 27453 times)

0 Members and 8 Guests are viewing this topic.

Offline Helios

  • Premium Member
  • Gearhead
  • *
  • Posts: 1289
  • Karma: +4/-3
  • Play Hard; Drive Harder!
Re: Car died while driving
« Reply #50 on: December 29, 2011, 11:37:56 AM »
Quote from: Dave@DDMworks on December 29, 2011, 11:35:32 AM
Joey,

If that picture was taken while the car is off, then the actuator is in the correct position, when you start the car the lever should swing approx. 90 degrees.

Let me know.
Dave


That pic was taken when the car was off, but it does not move 90 degrees when I start the engine.
Logged
"Gwyneth"
V8 swap in progress
RPi GT/ SOLO Exhaust

Offline Dave@DDMworks

  • Vendor
  • Gearhead
  • *
  • Posts: 1044
  • Karma: +11/-0
    • DDMworks
Re: Car died while driving
« Reply #51 on: December 29, 2011, 12:27:27 PM »
Quote from: Helios on December 29, 2011, 11:37:56 AM
That pic was taken when the car was off, but it does not move 90 degrees when I start the engine.

There are 2 possibilities, either the vacuum line has a hole in it or has come off of the supercharger outlet manifold, or the canister is bad. To check, pull the vacuum line off of the supercharger outlet manifold and suck on it really hard, you should see the rod move. If not, that actuator has died and a new one will be on the way ;)

Thanks,
Dave
Logged
Dave Michel
DDMWorks
Sales - 864-438-4949
Tech Support - 864-907-6004
WWW.DDMworks.com
Dave@DDMWorks.com

Stage 3 Supercharged 2.4L - 314whp - 93 octane
Rotrex Supercharged 2.4L - 303whp - 93 octane
2871 Hybrid turbo 2.0L - 371whp - 93 octane

Offline elff

  • Premium Member
  • General Manager
  • *
  • Posts: 11381
  • Karma: +26/-58
Re: Car died while driving
« Reply #52 on: December 29, 2011, 12:31:20 PM »
Critter, do you have any gauges to monitor yours?
I can't remember from when you let me drive it.

Us turbo guys have the DIC at least to monitor boost to a level.  I would bet that not working properly is messing up the boost and why you are feeling its off.

Logged

Offline Helios

  • Premium Member
  • Gearhead
  • *
  • Posts: 1289
  • Karma: +4/-3
  • Play Hard; Drive Harder!
Re: Car died while driving
« Reply #53 on: December 29, 2011, 12:44:12 PM »
Quote from: Dave@DDMworks on December 29, 2011, 12:27:27 PM
There are 2 possibilities, either the vacuum line has a hole in it or has come off of the supercharger outlet manifold, or the canister is bad. To check, pull the vacuum line off of the supercharger outlet manifold and suck on it really hard, you should see the rod move. If not, that actuator has died and a new one will be on the way ;)

Thanks,
Dave


In an earlier post I mentioned that the silver disk has a threaded hole. Is there supposed to be a set screw in there? Because mine does not. What thread size is said set screw? I'll have to do your test when I get home.
Logged
"Gwyneth"
V8 swap in progress
RPi GT/ SOLO Exhaust

Offline elff

  • Premium Member
  • General Manager
  • *
  • Posts: 11381
  • Karma: +26/-58
Re: Car died while driving
« Reply #54 on: December 29, 2011, 12:45:57 PM »
Please have someone filming you during this test.
YouTube stardom is crying out for you
:D
Logged

Offline Helios

  • Premium Member
  • Gearhead
  • *
  • Posts: 1289
  • Karma: +4/-3
  • Play Hard; Drive Harder!
Re: Car died while driving
« Reply #55 on: December 29, 2011, 12:52:54 PM »
Quote from: elff on December 29, 2011, 12:45:57 PM
Please have someone filming you during this test.
YouTube stardom is crying out for you
:D

I wondered how long it would be before someone jumped on that. Funny! I'll try to get my girlfriend to do it instead and film her.
Logged
"Gwyneth"
V8 swap in progress
RPi GT/ SOLO Exhaust

Offline Dave@DDMworks

  • Vendor
  • Gearhead
  • *
  • Posts: 1044
  • Karma: +11/-0
    • DDMworks
Re: Car died while driving
« Reply #56 on: December 29, 2011, 12:54:26 PM »
Quote from: Helios on December 29, 2011, 12:44:12 PM
In an earlier post I mentioned that the silver disk has a threaded hole. Is there supposed to be a set screw in there? Because mine does not. What thread size is said set screw? I'll have to do your test when I get home.

That is just a spacer and does not need the set screw in it, I will look around and see if I have any extra set screws for that spacer. Let me know on the actuator itself if you need one, and we will need video proof ;)
Logged
Dave Michel
DDMWorks
Sales - 864-438-4949
Tech Support - 864-907-6004
WWW.DDMworks.com
Dave@DDMWorks.com

Stage 3 Supercharged 2.4L - 314whp - 93 octane
Rotrex Supercharged 2.4L - 303whp - 93 octane
2871 Hybrid turbo 2.0L - 371whp - 93 octane

Offline Helios

  • Premium Member
  • Gearhead
  • *
  • Posts: 1289
  • Karma: +4/-3
  • Play Hard; Drive Harder!
Re: Car died while driving
« Reply #57 on: December 29, 2011, 12:57:44 PM »
Quote from: Dave@DDMworks on December 29, 2011, 12:54:26 PM
That is just a spacer and does not need the set screw in it, I will look around and see if I have any extra set screws for that spacer. Let me know on the actuator itself if you need one, and we will need video proof ;)

The things I will do for the community. OK, I WILL take a video of this when get around to it. Should make for some good laughs. I WILL NOT post it on youtube however. SICKOS!!!
Logged
"Gwyneth"
V8 swap in progress
RPi GT/ SOLO Exhaust

Offline elff

  • Premium Member
  • General Manager
  • *
  • Posts: 11381
  • Karma: +26/-58
Re: Car died while driving
« Reply #58 on: December 29, 2011, 01:16:47 PM »
 :lol:
Your a good sport!
Logged

Offline Critterman

  • Retired, thank you very much
  • Premium Member
  • General Manager
  • *
  • Posts: 13709
  • Karma: +18/-58
  • Baltimore/Washington Corridor
Re: Car died while driving
« Reply #59 on: December 29, 2011, 01:37:17 PM »
Dave, Yes I have a digital vacumn/boast gauge and a AFR gauge.  Plus you can read boast off of the Dashhawk, if you have it set to that PID.
Logged
GONE: (but not forgotten) 2006 Cool named IXABEL (BISH-AH-BEL) Mayan for "Good Roads"
DDM StageIII intercooled Supercharger, Wisco ceramic coated pistons, Carrillo rods, superTech valves and Springs, Ported and polished head, Exedy Stage II Clutch,
big brake kit, slotted/drilled Rotors w/Porterfield pads & blue juice, Backbone, Probeam, Cross Strut Brace Underhood, trunk, & door Lights, ZOK suspension
JPM Center console, door inserts, & dash Seat bolster & lumbar support
Focuztech Tri-Y Header & hi-flow cat, Solo Performance SQR-2, Norm's Rear facia, Heated Seats, Blackface gau

Offline Sol Asylum

  • Premium Member
  • General Manager
  • *
  • Posts: 10383
  • Karma: +41/-66
  • My car identifies as transportation
Re: Car died while driving
« Reply #60 on: December 29, 2011, 02:24:15 PM »
Quote from: Dave@DDMworks on December 29, 2011, 12:27:27 PM
suck on it really hard, you should see the rod move...
Thanks,
Dave

Poor choice of word or is Dave trying to tell you he has had enough with your car? :poke:
Logged
2007 Aggressive GXP

Offline Critterman

  • Retired, thank you very much
  • Premium Member
  • General Manager
  • *
  • Posts: 13709
  • Karma: +18/-58
  • Baltimore/Washington Corridor
Re: Car died while driving
« Reply #61 on: December 29, 2011, 02:38:42 PM »
SA that could simply be test instructions or perhaps a statement.
Logged
GONE: (but not forgotten) 2006 Cool named IXABEL (BISH-AH-BEL) Mayan for "Good Roads"
DDM StageIII intercooled Supercharger, Wisco ceramic coated pistons, Carrillo rods, superTech valves and Springs, Ported and polished head, Exedy Stage II Clutch,
big brake kit, slotted/drilled Rotors w/Porterfield pads & blue juice, Backbone, Probeam, Cross Strut Brace Underhood, trunk, & door Lights, ZOK suspension
JPM Center console, door inserts, & dash Seat bolster & lumbar support
Focuztech Tri-Y Header & hi-flow cat, Solo Performance SQR-2, Norm's Rear facia, Heated Seats, Blackface gau

Offline Helios

  • Premium Member
  • Gearhead
  • *
  • Posts: 1289
  • Karma: +4/-3
  • Play Hard; Drive Harder!
Re: Car died while driving
« Reply #62 on: December 29, 2011, 02:47:52 PM »
Quote from: Sol Asylum on December 29, 2011, 02:24:15 PM
Poor choice of word or is Dave trying to tell you he has had enough with your car? :poke:

Enough of my car? Nah, Dave LOVES my car! Not as much as Critter's though. Dave loves everyone's cars that like to spend money with DDM and I have spent A LOT. So, he REARRY, REARRY, RUVs me!!!
Logged
"Gwyneth"
V8 swap in progress
RPi GT/ SOLO Exhaust

Offline ihawk95

  • Premium Member
  • Gearhead
  • *
  • Posts: 3087
  • Karma: +14/-28
Re: Car died while driving
« Reply #63 on: December 29, 2011, 03:17:23 PM »
I would hope the rod would move if you suck on it really hard.

We'll definitely need video evidence of this!  :D
Logged

Offline Helios

  • Premium Member
  • Gearhead
  • *
  • Posts: 1289
  • Karma: +4/-3
  • Play Hard; Drive Harder!
Re: Car died while driving
« Reply #64 on: December 29, 2011, 03:23:27 PM »
Quote from: ihawk95 on December 29, 2011, 03:17:23 PM
I would hope the rod would move if you suck on it really hard.

We'll definitely need video evidence of this!  :D

You're a pro. Come do a demo for me.  :lol:
Logged
"Gwyneth"
V8 swap in progress
RPi GT/ SOLO Exhaust

Offline elff

  • Premium Member
  • General Manager
  • *
  • Posts: 11381
  • Karma: +26/-58
Re: Car died while driving
« Reply #65 on: December 29, 2011, 03:31:29 PM »
Hahahahahahahahahahahahahahaha

We need some side by side comparisons
Logged

Offline ihawk95

  • Premium Member
  • Gearhead
  • *
  • Posts: 3087
  • Karma: +14/-28
Re: Car died while driving
« Reply #66 on: December 30, 2011, 08:24:52 PM »
You guys always want a demo!  :lol:
Logged

Offline POS VETT

  • Master Tech
  • ***
  • Posts: 883
  • Karma: +4/-3
  • AINT YRS
Re: Car died while driving
« Reply #67 on: December 30, 2011, 10:20:46 PM »
Only Diana would know ...
Logged

Offline GXPinKC

  • Premium Member
  • Gearhead
  • *
  • Posts: 3537
  • Karma: +2/-2
  • GXPinKC
    • KappaPerformance.com
Re: Car died while driving
« Reply #68 on: January 03, 2012, 11:23:48 AM »
Quote from: POS VETT on December 30, 2011, 10:20:46 PM
Only Diana would know ...


Come on Diana, come forward with a post to clarify!
Logged
Code 1100, Order#KCPDVV 04-28-2006, Delivery: 12-27-2006 

2007 Aggressive GXP, 5-speed, Ebony Leather seats w red accent stitching, Chrome Wheels, Air, 6-Disc, Monsoon, Sport Metallic Pedals & Premium Headliner.

MSRP $30,300 less $1,000 GMMC credit.  Deal: $28,180. ($2,120 under MSRP).


DDM Race Backbone, Probeam, & Red Cross Bay Brace
JPM Leather Center Console
Windrestrictor
MRZ Performance Billet Caps
Beach Party FBC
Solo Mach Exhaust

Offline ihawk95

  • Premium Member
  • Gearhead
  • *
  • Posts: 3087
  • Karma: +14/-28
Re: Car died while driving
« Reply #69 on: January 04, 2012, 08:37:53 AM »
Nah... Joey already said I was a pro and I thought he and his gf were working on the video. What more do you need?

Besides, I don't wanna hijack his thread. I wanna know if he got his car running right. :)
Logged

Offline Helios

  • Premium Member
  • Gearhead
  • *
  • Posts: 1289
  • Karma: +4/-3
  • Play Hard; Drive Harder!
Re: Car died while driving
« Reply #70 on: January 04, 2012, 09:07:57 AM »
Quote from: ihawk95 on January 04, 2012, 08:37:53 AM
I wanna know if he got his car running right. :)

Nope, not yet. The bypass valve is indeed dead on my S/C. Dave is supposed to be sending me a new one.
Logged
"Gwyneth"
V8 swap in progress
RPi GT/ SOLO Exhaust

Offline JimmyBaja

  • Premium Member
  • Gearhead
  • *
  • Posts: 1147
  • Karma: +0/-1
Re: Car died while driving
« Reply #71 on: January 04, 2012, 09:35:13 AM »
Helios, the set screw in that spacer backed out on mine some time ago, I found a slightly longer one at Lowe's and put a small drop of blue Locktite on it to hold. I noticed with it loose the butterfly valve (bypass) shaft had some longitudal play causing the valve to not seat properly or close all the way.
Logged
Pages: 1 2 [3]   Go Up